S200系列通用矢量变频器说明书第1章安全及注意事项第1章安全及注意事项1.1安全事项1、应由电气专业技术人员安装、调试变频器，否则有触电危险！2、接线前请确认电源处于关断状态，否则有触电危险！3、接地端子必须可靠接地，接地电阻应小于0.1Q!4、不能将输入电源连到输出端U、V、W,否则引起变频器损坏！5、确保配线导线线径符合技术标准，否则可能发生事故！6、变频器无须进行耐压测试，出厂时产品此项己做过测试，否则可能引起事故！7、上电后不要触摸变频器端子（含控制端子），否则有触电危险！8、若要进行参数自学习，请注意电机旋转中伤人的危险，否则可能引起事故！9、不要采用接触器通断的方式来控制变频器的启停，否则引起设备损坏！10、断开电源后因滤波电容上仍然有高压，所以不能马上对变频器进行维修或保养，必须等待5分钟以上后用万用表测母线电压((+)和(-)之间的电压)不超过36V才可进行。11、不可将接地端子PE和电源零线N端子共用！1.2注意事项1、电机绝缘检查绝缘检查时一定要将电机连线从变频器分开，建议采用500V电压型兆欧表，应保证测得绝缘电阻不小于5M2。2、关于电动机发热及噪音因变频器输出电压是P波，含有一定的谐波，因此电机的温升、噪音和根动同工频运行相比会略有增加。3、输出侧禁止连接压敏器件或改善功率因素的电容4、雷电冲击保护本系列变频器内装有雷击过电流保护装置，对于感应雷有一定的自我保护能力。对于雷电频发处，用户还应在变频器前端加装防雷保护。5、变频器报废时注意主回路的电解电容和印制板上电解电容焚烧时可能发生爆炸，塑胶件焚烧时会产生有毒气体，请作为工业垃圾进行处理。6、电机线过长时注意电机电缆长度大于50m时，建议加装输出电抗器或输出滤波器，电机电缆长度超过100m的，必须加装输出电抗器或输出滤波器，否则电机绝缘易损坏。7、变频器应在符合设计规格要求的环境下使用，否则可能造成故障因不遵守相关规定引发的功能异常或部件损坏等不在产品质量保证范围之内，例：在潮湿、有导电灰尘或腐蚀性气体等特殊的场合，不建议使用。1第2章技术指标及选型S200系列通用矢量变频器说明书第2章技术指标及选型2.1命名规则S200-G15/P18.5T4B/Z/F-ET-C/2C/3C/E/2ES200:通用矢量变频器S220-F:无纺布设备专用变频器升级版本S230-QW:球磨机专用变频器S260-H/GH:工程型矢量变频器标识制动单元S270-PS:移动式破碎机专用变频器空无S270-QS:固定式破碎机专用变频器B/Z含制动单元S280-FB:厂用防爆变频器通用机芯F带辅机S280-G:中压防爆变频器热管机芯ET一体机S290-LD:标准件设备专用变频器标识机型标识输入电压等级G通用型T2三相220士15%风机水泵型T4三相380士15%T6三相690士10%适配电机功率标识0.4-1200电机功率0.4KW-1200KW注：1)G22KW、G30KW机型变频器，若用到制动时，需购买我司内置制动模块的-B机型。2)G37KW及以上机型变频器，若用到制动时，需购买我司外置制动单元。2.2铭牌CHiNSC型号规格MODEL:S200-G15/P18.5T4B-C输入规格INPUT:AC 3PH 380V +15%50/60Hz输出规格OUTPUT:AC 3PH 0-380V 0-3000Hz 32/37A产品批号S/N:Shandong Chinsc Drive Technology Ca,Ltd2S200系列通用矢量变频器说明书第2章技术指标及选型2.3型号与技术参数S200系列220V变频器型号与技术参数变频器型号输入电压V电源容量KVA输入电流A输出电流A适配电机KWS200-G0.4T2B-C1.53.42.10.4S200-G0.75T2B-C3.05.03.80.75S200-G1.5T2B-C5.08.071.5S200-G2.2T2B-C5.910.592.2S200-G3.0T2B-C8.914.6133.0S200-G3.7T2B-C11.020.5173.7S200-G5.5T2B-C17.026.0255.5S200-G7.5T2B-C21.035.0327.5S200-G11T2B-C24.038.53711S200-G15T2B-C30.046.54515S200-G18.5T2B-C40.062.06018.5S200-G22T2-C57.076.07522三相220VS200-G30T2-C69.092.09130S200-G37T2-C85.0113.011237S200-G45T2-C114.0157.015045S200-G55T2-C134.0180.017655S200-G75T2-C192.0256.025375S200-G93T2-C231.0307.030493S200-G110T2-C242.0350.0340110S200-G132T2-C280.0430.0426132S200-G160T2-C396.0525.0520160S200-G185T2-C445.0590.0585185S200-G200T2-C500.0665.0650200S200-G220T2-C565.0785.0725220S200-G250T2-C650.0825.08202503第2章技术指标及选型S200系列通用矢量变频器说明书S200-C系列380V变频器型号与技术参数变频器型号输入电压V电源容量KVA输入电流A输出电流A适配电机KWS200-G0.4T4B-C1.02.41.20.4S200-G0.4T4B-3CS200-G0.75T4B-C1.53.42.50.75S200-G0.75T4B-3CS200-G1.5T4B-C3.05.03.71.5S200-G1.5T4B-3CS200-G2.2T4B-C4.05.85.02.2S200-G2.2T4B-3CS200-G3.0/P3.7T4B-C5.08.07/93.0/3.7S200-G3.0/P3.7T4B-3CS200-G3.7/P5.5T4B-C5.910.59/133.7/5.5S200-G3.7/P5.5T4B-3CS200-G5.5/P7.5T4B-C8.914.613/175.5/7.5S200-G5.5/P7.5T4B-3CS200-G7.5/P11T4B-C11.020.517/257.5/11S200-G7.5/P11T4B-3C三相380VS200-G11/P15T4B-C17.026.025/3211/15S200-G11/P15T4B-3CS200-G15/P18.5T4B-C21.035.032/3715/18.5S200-G15/P18.5T4B-3CS200-G18.5/P22T4B-C24.038.537/4518.5/22S200-G18.5/P22T4B-3CS200-G22/P30T4B-C30.046.545/6022/30S200-G30/P37T4B-C40.062.060/7530/37S200-G37/P45T4-C57.076.075/9037/45S200-G45/P55T4-C69.092.090/11045/55S200-G55/P75T4-C85.0113.0110/15055/75S200-G75/P93T4-C114.0157.0150/17675/93S200-G93/P110T4-C134.0180.0176/21093/110S200-G110/P132T4-C160.0214.0210/253110/132S200-G132/P160T4-C192.0256.0253/300132/160S200-G160/P185T4-C231.0307.0300/340160/185S200-G185/P200T4-C242.0350.0340/380185/2004S200系列通用矢量变频器说明书第2章技术指标及选型S200-G200/P220T4-C250.0385.0380/420200/220S200-G220/P250T4-C280.0430.0420/470220/250S200-G250/P280T4-C355.0468.0470/520250/280S200-G280/P315T4-C396.0525.0520/600280/315S200-G315/P350T4-C445.0590.0600/640315/350S200-G350/P400T4-C500.0665.0640/690350/400S200-G400/P450T4-C565.0785.0690/800400/450S200-G450/P500T4-C650.0825.0800/900450/500S200-G500/P550T4-C700.0883.0900/980500/550S200-G550T4-C770.0975.0980550S220系列变频器型号与技术参数变频器型号输入电压V电源容量KVA输入电流A输出电流A适配电机KWS220-WF0.4T4B-2E1.02.41.20.4S220-WF0.75T4B-2E1.53.42.50.75S220-WF1.5T4B-2E3.05.03.71.5S220-WF2.2T4B-2E4.05.85.02.2S220-WF3.0T4B-2E5.08.03.0S220-WF3.7T4B-2E5.910.593.7S220-WF5.5T4B-2E8.914.6135.5S220-WF7.5T4B-2E11.020.5177.5S220-WF11T4B-2E17.026.02511S220-WF15T4B-2E21.035.03215S220-WF18.5T4B-2E24.038.53718.5三相380VS220-WF22T4B-2E30.046.54522±15%S220-WF30T4B-E40.062.06030S220-WF37T4B-E57.076.07537S220-WF45T4-E69.092.09045S220-WF55T4-E85.0113.011055S220-F75T4-E114.0157.015075S220-WF93T4-E134.0180.017693S220-W℉110T4-E160.0214.0210110S220-WF132T4-E192.0256.0253132S220-WF160T4-E231.0307.0300160S220-W℉185T4-E242.0350.0340185S220-WF200T4-E250.0385.03802005第2章技术指标及选型S200系列通用矢量变频器说明书S220-WF220T4-E280.0430.0420220S220-WF250T4-E355.0468.0470250S220-WF280T4-E396.0525.0520280S220-WF315T4-E445.0590.0600315S220-WF350T4-E500.0665.0640350S220-WF400T4-E565.0785.0690400S220-F450T4-E650.0825.0800450S220-WF500T4-E700.0883.0900500S220-WF550T4-E770.0975.0980550S230系列变频器型号与技术参数变频器型号输入电压V电源容量KVA输入电流A输出电流A适配电机KWS230-QM22T4B/Z-ET-E30.046.54522S230-QM30T4B/Z-ET-E40.062.06030S230-QM37T4/Z-ET-E57.076.07537S230-QM45T4/Z-ET-E69.092.09045S230-QM45T4/F-ET-ES230-QM55T4/Z-ET-E85.0113.011055S230-QM55T4/F-ET-ES230-QM75T4/Z-ET-E114.0157.015075S230-QM75T4/F-ET-ES230-QM93T4/F-ET-E134.0180.017693S230-QM110T4/F-ET-E160.0214.0210110S230-QM132T4/F-ET-E192.0256.0253132三相380VS230-QM160T4/F-ET-E±15%231.0307.0300160S230-QM185T4/F-ET-E242.0350.0340185S230-QM200T4/F-ET-E250.0385.0380200S230-QM220T4/F-ET-E280.0430.0420220S230-QM250T4/F-ET-E355.0468.0470250S230-QM280T4/F-ET-E396.0525.0520280S230-QM315T4/F-ET-E445.0590.0600315S230-QM350T4/F-ET-E500.0665.0640350S230-QM400T4/F-ET-E565.0785.0690400S230-QM450T4/F-ET-E650.0825.0800450S230-QM500T4/F-ET-E700.0883.0900500S230-QM550T4/F-ET-E770.0975.09805506S200系列通用矢量变频器说明书第2章技术指标及选型S230-QM630T4/F-ET-E1000.01400.01100630S260-K阳系列变频器型号与技术参数变频器型号输入电压V电源容量KVA输入电流A输出电流A适配电机KWS260-KH30T4B-C40.062.06030S260-KH37T4B-C57.076.07537S260-KH45T4-C69.092.09045S260-KH55T4-C85.0113.011055S260-KH75T4-C114.0157.015075S260-KH93T4-C134.0180.017693S260-KH110T4-C160.0214.0210110S260-KH132T4-C192.0256.0253132S260-KH160T4-C231.0307.0300160S260-KH185T4-C242.0350.0340185S260-KH200T4-C250.0385.0380200S260-KH220T4-C三相380V280.0430.0420220±15%S260-KH250T4-C355.0468.0470250S260-KH280T4-C396.0525.0520280S260-KH315T4-C445.0590.0600315S260-KH350T4-C500.0665.0640350S260-H400T4-C565.0785.0690400S260-H450T4-C650.0825.0800450S260-KH500T4-C700.0883.0900500S260-KH550T4-C770.0975.0980550S260-K630T4-C1000.01400.01100630S260-K700T4-C1200.01450.01300700S260-KH800T4-C1400.01650.014508007第2章技术指标及选型S200系列通用矢量变频器说明书S260-GH系列变频器型号与技术参数变频器型号输入电压V电源容量KVA输入电流A输出电流A适配电机KWS260-GH30T4B-C40.062.06030S260-GH37T4B-C57.076.07537S260-GH45T4-C69.092.09045S260-GH55T4-C85.0113.011055S260-GH75T4-C114.0157.015075S260-GH93T4-C134.0180.017693S260-GH110T4-C160.0214.0210110S260-GH132T4-C192.0256.0253132S260-GH160T4-C231.0307.0300160S260-GH185T4-C242.0350.0340185S260-GH200T4-C250.0385.0380200S260-GH220T4-C280.0430.0420220S260-GH250T4-C三相380V355.0468.0470250S260-GH280T4-C±15%396.0525.0520280S260-GH315T4-C445.0590.0600315S260-GH350T4-C500.0665.0640350S260-GH400T4-C565.0785.0690400S260-GH450T4-C650.0825.0800450S260-GH500T4-C700.0883.0900500S260-GH550T4-C770.0975.0980550S260-GH630T4-C1000.01400.01100630S260-GH700T4-C1200.01450.01300700S260-GH800T4-C1400.01650.01450800S260-GH900T4-C1550.01700.01630900S260-GH1000T4-C1650.01800.017601000S260-GH1200T4-C1900.02050.0200012008S200系列通用矢量变频器说明书第2章技术指标及选型S270-PS系列变频器型号与技术参数变频器型号输入电压V电源容量KVA输入电流A输出电流A适配电机KWS270-PS11T4B-E17.026.025.011S270-PS15T4B-E21.035.032.015S270-PS18.5T4B-E24.038.537.018.5S270-PS22T4B-E30.046.545.022S270-PS30T4B-E40.062.060.030S270-PS37T4-E57.076.075.037S270-PS45T4-E69.092.090.045S270-PS55T4-E85.0113.0110.055S270-PS75T4-E114.0157.0150.075S270-PS93T4-E134.0180.0176.093S270-PS110T4-E160.0214.0210.0110S270-PS132T4-E192.0256.0253.0132S270-PS132T4-L-ES270-PS160T4-E231.0307.0300.0160S270-PS160T4-L-ES270-PS185T4-E242.0350.0340.0185S270-PS185T4-L-E三相380VS270-PS200T4-E±15%250.0385.0380.0200S270-PS200T4-L-ES270-PS220T4-E280.0430.0420.0220S270-PS220T4-L-ES270-PS250T4-ES270-PS250T4-L-E355.0468.0470.0250S270-PS250T4-L-XS270-PS280T4-ES270-PS280T4-L-E396.0525.0520.0280S270-PS280T4-L-XS270-PS315T4-ES270-PS315T4-L-E445.0590.0600.0315S270-PS315T4-L-XS270-PS350T4-E500.0665.0640.0350S270-PS350T4-L-ES270-PS400T4-E565.0785.0690.0400S270-PS400T4-L-E9